炼钢 ›› 2025, Vol. 41 ›› Issue (4): 51-58.

• 凝固与浇铸 • 上一篇    下一篇

大方坯连铸结晶器流体运动行为的水模研究

布燊川1,肖远悠1,张达先2,何建中2,王国承1,3   

  1. 1.辽宁科技大学 材料与冶金学院,辽宁 鞍山 114051; 
    2.内蒙古包钢钢联股份有限公司 技术中心,内蒙古 包头 014010;
    3.辽宁省高校冶金工程重点实验室,辽宁 鞍山114051
  • 出版日期:2025-08-05 发布日期:2025-07-31

Water modeling study of fluid flow in a bloom continuous casting mold

  • Online:2025-08-05 Published:2025-07-31

摘要: 以某钢厂380 mm×280 mm大方坯连铸结晶器为原型,建立1∶1水模型,研究了结晶器内的流场行为和现象,并根据预测结果,最终确定了拉速优化参数。结果表明:结晶器内存在不对称的流场分布现象;与提高拉速相比,增加水口插入深度,钢液冲击深度的增幅更大;结晶器液面具有窄面、角部和水口附近波动大,而宽面附近波动小的特点;随着拉速的增加,渣层波动加剧,渣层的最小厚度减小;随着水口插入深度的增加,渣层波动减弱,渣层的最小厚度增大;拉速提高至0.67 m/min时,建议水口插入深度保持在135~150 mm。

关键词: 大方坯结晶器, 流场, 液面波动, 保护渣, 水模型

Abstract: Based on the prototype, a 380 mm×280 mm bloom mold in a steel plant, the 1∶1 water model was established to study the flow field and phenomena in mold. According to the prediction results, the optimization parameters of casting speed were finally determined. The findings can be summarized as follows. In the mold, an asymmetric flow field was observed. Compared with increasing the casting speed, the increase of the impact depth of jet flow is greater with increasing the immersion depth of SEN. The level fluctuation in mold is larger near the narrow face, the corner and the SEN, while it is smaller near the wide face. With the increase of casting speed, the slag layer fluctuates more violently and the minimum thickness is reduced. With increasing the immersion depth of SEN, the fluctuation of slag layer is weakened and the minimum thickness increases. When the casting speed is set at 0.67 m/min, the recommended immersion depth of SEN is 135-150 mm.

Key words: bloom mold, flow field, level fluctuations, mold slag, water model